British Columbia Mine Reclamation Symposia

Tailings revegetation experience at Cominco Ltd. metal mines in British Columbia and the Northwest Territories Gardiner, Robert T. 1977-12-31

You don't seem to have a PDF reader installed, try download the pdf

Item Metadata

Download

Media
[if-you-see-this-DO-NOT-CLICK]
1977 - Gardiner - Tailings Revegetation Experience.pdf [ 676.35kB ]
Metadata
JSON: 1.0041986.json
JSON-LD: 1.0041986+ld.json
RDF/XML (Pretty): 1.0041986.xml
RDF/JSON: 1.0041986+rdf.json
Turtle: 1.0041986+rdf-turtle.txt
N-Triples: 1.0041986+rdf-ntriples.txt
Original Record: 1.0041986 +original-record.json
Full Text
1.0041986.txt
Citation
1.0041986.ris

Full Text

st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  35  TAILINGS REVEGETATION EXPERIENCE AT COMINCO LTD. METAL MINES IN BRITISH COLUMBIA AND THE NORTHWEST TERRITORIES  COMINCO LTD. R.T. Gardiner, P.Ag. Reclamation Agronomist 1977  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  37  A fellow "reclamationist", with experience primarily in coal mine reclamation, recently commented that revegetation of tailings was less of a challenge than coal mine waste because tailings were relatively uniform and limited in area. In terms of certain factors, such as particle size and slope conditions, this may be true; however, as I hope to illustrate, tailings and tailings properties which influence plant life can be extremely variable, and not only among sites but within tailings deposits and with time.  Cognizance of this fact is an important prerequisite to development  of effective and efficient tailings revegetation programs and to the formulation of realistic guidelines, standards or regulations for tailings reclamation. Information to illustrate variability in climate, mineralogy, chemical and physical characteristics, factors limiting plant growth and in cultural techniques for mitigating growth limiting factors and establishing vegetation on tailings from Cominco mining properties at Benson Lake, Pinchi Lake, Salmo, Kimberley, Pine Point and Yellowknife is presented.  1. Variability in Tailings Characteristics and Factors Limiting Plant Growth Cominco mining properties are distributed among several biogeoclimatic zones in British Columbia and the Northwest Territories which represent a wide range of climatic conditions which influence plant growth (1, 2, 3) (Table 1). Economic and gangue minerals as well as size of the tailings deposit vary among mining properties (Table 2). than one type of tailings exists.  At some properties, more  In most disposal sites, partial  segregation or redistribution of the various mineral and size fractions occurs during deposition resulting in a deposit with variable chemical and physical characteristics both over the surface and with depth.  Variation  in tailings characteristics can develop over time as result of modifications in mining, milling and disposal techniques and physical, chemical and biological reactions which occur within the tailings deposit following exposure to the atmosphere.  The variation in tailings physical  and chemical characteristics, evaluated to assess the suitability of tailings as growth media for plants, and more specifically, to identify  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  38  potential growth limiting factors, is demonstrated (Tables 3, 4, 5). Available supplies of essential plant nutrients, tailing reaction, salt concentrations, total S, calcium carbonate equivalence, cation exchange capacity, particle size distribution, particle and bulk density and available moisture holding capacity vary both within and among tailings deposits and with time.  The specific relationships between certain tailings physical  and chemical characteristics as determined by analytical techniques and the potential for sustaining plant growth on tailings are not well defined. However, by comparing tailings values with those of soil with known plant growth potential, at least the nature, if not the degree of severity, of certain growth limiting factors can be identified. Growth limiting factors associated with Cominco tailings include: deficiencies of one or more essential plant nutrients including N, P, K, Ca, Mg, B and possibly others; extremes of acidity and possibly alkalinity; excessive concentrations of salts and, in areas of limited precipitation, moisture stress (Table 5).  Surface crusting, formation of hard, impermeable  strata, movement of tailings by wind action and limited pore volume are growth limiting factors observed during site inspection.  Usually more than  one growth limiting factor has been identified within a specific tailings disposal area.  Some care and caution must be exercised when sampling  tailings and interpreting analytical data.  Sampling sites should be  representative of the range of conditions existing near the surface and with depth.  Chemical and physical characteristics of recently deposited tailings  containing reactive sulfide minerals can change substantially within a short time period and may continue to change for an indeterminate period to time. Under semi-arid conditions, salt concentrations near the surface of saline tailings deposits change during the growth season, generally increasing during periods of low precipitation and high evaporation.  2. Amelioration of Growth Limiting Factory Associated With Tailings Improving tailings as a growth medium for plants is one of the first alternatives considered in developing a revegetation plan. Other alternatives include selection of plant species having tolerance of specific growth limiting  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  39  factors and covering the tailings with a more suitable medium. Experimenting with alternative techniques for ameliorating chemical and physical conditions which severely limit plant growth on tailings is a major part of Cominco's reclamation program.  However, in most situations  encountered to date, selection of specially adapted plant species in combination with improvements to the growth medium, either by addition of amendments or by covering with a less toxic growth medium, may be required for effective and efficient reclamation.  2.1 Deficiencies of Essential Plant Nutrients Plant growth on tailings is severely limited by deficiencies of one or more essential plant nutrients. All Cominco tailings evaluated to date have "plant available" nitrogen and phosphorus concentrations in the "very low" range (Table 3).  Growth room investigations have confirmed that application  of both nitrogen and phosphorus is essential for satisfactory growth of grass on tailings.  "Available" potassium concentrations are generally in  the "very low to low" range, however, eliminating potassium from a nutrient mix applied to tailings does not limit grass growth as severely as eliminating nitrogen or phosphorus.  "Available" magnesium concentrations  range from "very low" to "very high", however, as was observed with potassium, plant growth was not severely limited when magnesium was not added to tailings.  Tailings deficient in magnesium are generally acid in  reaction. Application of dolomite to improve tailings reaction will generally provide sufficient magnesium for plant growth. In contrast to tailings, gypsum, a waste product of phosphoric acid manufacture, contains "very high" concentrations of phosphorus and satisfactory growth of grass and legume species was possible without addition of phosphorus. Grass growth on gypsum was, however, limited by deficiencies of nitrogen, potassium and magnesium. Alfalfa developed symptoms characteristic of boron deficiency when growing on gypsum limed with dolomite. In addition to limiting growth of agricultural species, nutrient deficiencies restrict natural revegetation of non-toxic tailings deposits by native plant  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  40  species. Application of a nutrient mix containing nitrogen, phosphorus and potassium to Pinchi Lake tailings initiated establishment of native herbaceous and woody plant species within the fertilized area.  Similarly,  native grass species have invaded fertilized experimental areas on slightly to moderately saline Con tailings in which seeded species did not establish or sustain growth.  Growth of native species was observed on tailings  supplied by nutrients released by mineralization of plant residues originating from vegetation growing adjacent to the tailings deposit and from decaying trees partially submerged within the tailings deposit. Chemical fertilizers are a convenient source of plant nutrients for promoting growth on tailings.  Growth room and field investigations have demonstrated  that excellent plant growth can be established and sustained on non-toxic tailings by applying fertilizers.  However, specific information for planning  effective and efficient fertilizer use in tailings revegetation programs is limited.  Improperly planned fertilizer programs can be costly in terms of  wasteful use of an important limited resource, unnecessary applications and increased potential for surface and groundwater contamination.  Fertilizer  nitrogen can be lost as result of leaching, volatilization and denitrification. Careful consideration of nitrogen source, rate, time and method of application can minimize losses.  Since tailings are generally  coarse textured, with a very low cation exchange capacity, leaching of potassium and magnesium fertilizers from the root zone is possible. Phosphorus fertilizers react with mineral constituents of tailings forming reaction products of low water solubility. is relatively immobile.  Following reversion, phosphorus  Efficiency of phosphorus use is dependent,  therefore, on solubility of the reaction product and position of the reaction product relative to absorbing roots. At the Land Reclamation short course, held at U.B.C. in March 1974, Dr. Beaton, Chief Agronomist at Cominco, presented an excellent discussion of soil-plant nutrient relationships together with general comments on more effective use of fertilizers in mine and mill waste revegetation programs (Table 4).  Dr. Beaton's comments were  based on many years of research and experience with fertilizer use in agriculture. To improve efficiency of fertilizer use in tailings  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  41  revegetation programs, however, more research is required to improve fertilizer recommendations and application techniques. In addition to improving the efficiency of fertilizer use, alternative sources of plant nutrients should be considered.  Agricultural and  municipal organic wastes, if conveniently situated, have potential as sources of plant nutrients, as well as for improving physical properties such as infiltration and retention of water.  Care should be taken not to  select organic residues with C:N ratios in excess of 20 to 25:1.  Addition  of substantial amounts of organic residues with wider C:N ratios would likely induce or aggravate nitrogen deficiency since available nitrogen in tailings would be used by micro-organisms responsible for organic matter breakdown.  Addition of plant nutrients can be reduced by establishing plant species with the capacity of symbiotic associations with soil micro-organisms capable of assimilating alternate or less available forms of a limiting plant nutrient.  To illustrate, a significant deterioration in grass  stands growing on tailings discontinued.  occurs when annual nitrogen applications are  This suggests a necessity for a maintenance nitrogen  program for an, as yet, undetermined number of years to sustain satisfactory growth of grasses.  Vegetation with a  significant component  of nitrogen-fixing species can, however, sustain satisfactory growth without maintenance nitrogen.  The use of nitrogen-fixing plant species is  a less costly alternative to a maintenance nitrogen program. Similarly, the availability of residual organic and inorganic forms of phosphorus may be increased by the selection of plant species capable of a symbiotic association with mycorrhizal organisms.  2.2 Acid Tailings Reaction Normal growth of most plant species is severely limited on soil with a pH less than 5.  Very few species of plants can survive on soil with a pH less than 4.  Weathered tailings from Cominco's Benson Lake and Sullivan properties have a pH in the range of 2 to 3.5.  Development of an extreme acid reaction in  tailings is generally the result of chemical and biological oxidation of iron  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  42  sulfide minerals, forms of which have been identified in all Cominco tailings materials.  An extreme acid reaction can develop relatively soon  after deposition and exposure to the atmosphere.  For example, freshly  deposited sulfide tailings have a neutral to slightly alkaline reaction, however, within a matter of a few months, extreme acidity may develop.  The  severity of the acid reaction is dependent, in part, on relative quantities of  reactive iron sulfide minerals and minerals capable of neutralizing acid  generated during oxidation, such as calcite and dolomite.  The phytotoxic  effects of extreme acidity can be alleviated by application of appropriate quantities of liming materials such as calcite, dolomite, hydrated lime and marl.  However, analytical techniques normally used to estimate "lime  requirement" of acid soils do not provide a realistic estimate of "lime requirement" of acid or potentially acid tailings (Table 6).  Less  convenient and relatively long term incubation and growth studies have demonstrated that the lime requirement of acid tailings is extremely high relative to that of acid soils and that it bears no relation to tailings pH. For example, quantities of CaC03 required to maintain a near neutral reaction throughout a combined growth and incubation period of one year, were 40, 97 and 125 mg/gm of Benson Lake tailings, Sullivan oxidized siliceous tailings and Sullivan oxidized iron tailings, respectively. Converted to tons per acre-foot, the values are equivalent to 92, 185 and 301 tons per acre, respectively.  The amount of CaC03 required to maintain a  near neutral reaction in fresh actively oxidizing siliceous tailings appears to be greater than that of oxidized siliceous tailings.  Addition of 110 mg  CaCO3 per gm of fresh siliceous tailings was not sufficient to prevent tailings pH from dropping to 5.5 during a 54-week growth and incubation period.  Without addition of CaCO3 tailings pH decreased from 6.2 to 2.6  during the same period. Oxidation of iron sulfide minerals can also result in increased salt concentrations, surface crusting and formation of hard impermeable strata at or near the tailings deposit surface.  Revegetation of acid tailings, therefore,  requires amelioration of other growth limiting factors which, in some instances, may be more difficult and costly to mitigate than the acid reaction.  Sullivan  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  43  iron tailings are a case in point.  In addition to nutrient deficiencies and  an extremely high lime requirement, iron tailings are strongly saline and have a hard, impermeable layer, up to 3" thick, either at or within nine inches of the surface.  Effective incorporation of liming materials is  essentially prevented by this adverse physical condition Tailings immediately below the impermeable layer are unoxidized, saturated and thixotropic, with insufficient bearing strength to support equipment.  As an  alternative to improving iron tailings as a growth medium, a less toxic industrial waste from Cominco's fertilizer operations at Kimberley is currently under evaluation. Gypsum, referred to earlier in this presentation, is disposed of on land immediately adjacent the iron tailings disposal area and has potential as a relatively low cost material for covering iron tailings.  Gypsum also has an  extremely acid reaction, however, relative to iron and siliceous tailings, the lime requirement is low.  Growth room studies have demonstrated that nitrogen-  fixing legume species alfalfa, birdsfoot trefoil and alsike clover, will grow satisfactorily on gypsum limed with 15 mg of dolomitic limestone per gm of gypsum and fertilized with up to 155 ppm potassium and 4 ppm boron.  In field  investigations initiated in the spring of 1976, birdsfoot trefoil, rambler alfalfa, hard fescue, tall wheatgrass, western wheatgrass and crested wheatgrass established satisfactorily on gypsum limed with the equivalent of 6 ton/acre-foot of hydrated lime.  Increasing hydrated lime rate to 18 ton/acre-  foot did not improve seedling establishment and growth during the first year, however, gypsum pH was maintained at a higher level of 7.4 compared to 6.0 for the lower lime rate.  Application of up to 22 ton/acre-foot of dolomitic  limestone did not raise gypsum pH above 5 1. satisfactorily on gypsum limed with dolomite.  Only grass species established In addition to low lime  requirement, gypsum is non-saline, "very high" in available phosophorus and does not possess the undesirable physical characteristics described for iron tailings.  Gypsum does, unfortunately, contain minor amounts of fluoride.  Legume and grass forage grown on gypsum limed with hydrated lime and sampled at the end of one growing season contained 80 to 310 ppm fluoride-F. Plants and plant products usually range from less than 1 to 16 ppm fluoride-F (5). Fluoride contents considered safe for animal consumption range from 30 to 400  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  44  ppm fluoride-F and depend on the form of fluoride and the type of livestock (5,  6).  2.3 Saline Tailing Plant growth on tailings can be severely limited by high concentrations of water soluble salts.  Salt concentrations in soils and other growth media  are measured and expressed in terms of the electrical conductivity of the soil solution.  Conductivities are usually measured on saturation extracts  and expressed in terms of millimhos per cm at 25°C.  Plants vary in  sensitivity to salts and once concentrations exceed 8 mmhos/cm, only salt tolerant species such as several wheatgrass species, tall fescue, Russian wild rye, birdsfoot trefoil and sweet clover grow satisfactorily. At conductivities above 16 mmhos/cm, only a few very tolerant plants grow satisfactorily. In addition to saline acid tailings, high salt concentrations occur in alkaline tailings at the Con mine at Yellowknife.  Conductivities for 43  surface tailings samples collected in July and August 1976 ranged from 2 to 54 mmhos/cm and averaged 25 mmhos/cm. Eighty-three percent, 67% and 47% of samples collected had conductivities greater than 8, 16 and 24 mmhos/cm, respectively.  Conductivities decreased with depth averaging 6 mmhos/cm  below the surface foot.  Discharge of saline mine water to the tailings pond  has contributed to development of a saline growth medium.  Subsequent  evaporation of tailings moisture results in upward migration and accumulation of salts in surface layers of tailings. In growth room studies, saline tolerant tall wheatgrass grew satisfactorily on tailings with a conductivity of 16 mmhos/cm.  Leaching with 1 cm water  per cm depth of tailings or addition of 75 mg peat moss per gm of tailings was necessary for growth of creeping red fescue, a less salt tolerant grass specie, to yield more than 50% of creeping red fescue yield on a non-saline agricultural soil.  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  45  Field studies on slightly to moderately saline tailings have demonstrated the capability of several grass species, including creeping red fescue, meadow foxtail, red top, reed canarygrass and crested wheatgrass to sustain growth for at least three years under severe climatic stress in the Yellowknife area The highlight of the 1976 field program, however, was the successful establishment of four grasses and one legume on tailings which had proven too saline for seeding growth during two previous years  Favourable early season  precipitation is believed to have contributed to establishment of salt tolerant tall and western wheatgrasses, cold tolerant arctared creeping red fescue and foxtail barley and a salt tolerant legume, birdsfoot trefoil. Incorporation of up to 40 tons peat moss per acre-foot did not improve germination of first season growth.  At the end of the first growing season  tailings conductivities were similar for all peat rates and were in the order of 20 to 24 mmhos/cm. A large deposit of peat exists adjacent the tailings disposal area and has potential for use as a tailings amendment on an operational scale if field studies demonstrate that peat moss is effective for reducing salt concentrations. In addition, a visit to the Salt River alkali flats, in Wood Buffalo National Park, was made in mid-July and seed from a number of saline tolerant native plant species was collected for growth room and field evaluation  2.4 Accumulation of Potentially Toxic Metals by Vegetation Growing on Tailings Tailings generally contain metals in quantities greater than normally found in non-contaminated soil.  Monitoring vegetation growing on tailings for  potentially toxic metals cannot be overlooked when assessing the suitability of tailings as a growth medium or, for that matter, when assessing vegetation as an acceptable tailings reclamation alternative.  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  46  Vegetation grown on tailings at Cominco mining properties is being monitored for metals of concern to the specific area. As indicated earlier, elevated levels of fluoride accumulated in vegetation grown on gypsum.  Vegetation grown  on Con tailings contains arsenic in widely ranging concentrations from 10 ppm to 260 ppm.  By comparison, vegetation grown on soil in the Yellowknife area  ranged from 6 ppm to 44 ppm As.  Grass forage grown on limed, actively  oxidizing siliceous tailings in a growth room environment averaged 865 ppm Zn. Addition of the equivalent of 100 and 203 cons of sewage sludge per 1,000 tons of tailings increased Zn content of forage to 1,370 ppm and 1,814 ppm, respectively.  In contrast, grass grown on limed siliceous tailings which has  been exposed to atmospheric conditions for 30 or more years, averaged only 59 ppm Zn.  Grass forage grown on an uncontaminated soil daring the same  experiment contained 50 ppm Zn. The mercury content of twenty-eight grass and legume forage samples grown on Pinchi Lake tailings during 1976 ranged from 0.1 ppm to 1.5 ppm and averaged 0.4 ppm. Mercury contents of terrestrial plants ranged from 10 to 200 ppb on normal soils and from 0.5 to 3.5 ppm in the vicinity of mercury deposits (7). Warren (8) reported mercury content of vegetation growing in the vicinity of mercury mineralization in B.C. ranging from 2.2 to 30 ppm. The copper content of grass forage grown on Benson Lake tailings during the 1975 growing season ranged from 5 ppm to 40 ppm. Normal range suggested for plants is 3 ppm to 40 ppm Cu (5).  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  47  References 1.  Krajina, V.J., 1969  2.  Climate of British Columbia Reports for 1974 and 1975. Atmospheric Environment Service, Environment Canada. Published by the British Columbia Dept of Agriculture.  3.  Ecology of Western North America Volume 2, No.lDept. of Botany, University of British Columbia  Rowe, J.S., 1972  Forest Regions of Canada, Department of the Environment, Canadian Forestry Service, Publication No.1300  4.  Beaton. J.D., 1974  Soil-Plant Relationships Proceedings of the Land Reclamation Short Course. Centre for Continuing Education, University of British Columbia  5.  Baker, D.E., 1976 Chesnin, L.  Chemical Monitoring of Soils for Environmental Quality and Animal Health. Advances in Agronomy 27:305-374. Academic Press, New York.  6.  Underwood, E.J., 1971  Trace Elements in Human and Animal Nutrition, 3rd Edition 543 pp Academic Press, New York.  7.  Mortvedt, J.J., 1972 Giordano Lindsay, W.L.  Micronutrients in Agriculture. Proceedings of Symposium. Muscle Shoals, April 20-22, 1971. Soil Science Society of America, Inc., Madison, Wisconsin.  8.  Warren, H.V., 1966 Delavault, R.E. Barosko, J.  Some Observations on the Geochemistry of Mercury as applied to Prospecting. Econ. Geol. Volume 61, No.6.  ________ R.T Gardiner Reclamation Agronomist Reclamation Research RTG: j f March 10, 1977  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  48  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  49  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  50 Table 3:  Available Plant Nutrient Concentrations in Tailings  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  51 Table 4:  Certain Chemical Properties of Tailings  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  52  st  Proceedings of the 1 Annual British Columbia Mine Reclamation Symposium in Vernon, BC, 1977. The Technical and Research Committee on Reclamation  53  

Cite

Citation Scheme:

        

Citations by CSL (citeproc-js)

Usage Statistics

Country Views Downloads
China 8 0
United States 5 0
Russia 1 0
City Views Downloads
Shenzhen 8 0
Ashburn 5 0
Saint Petersburg 1 0

{[{ mDataHeader[type] }]} {[{ month[type] }]} {[{ tData[type] }]}
Download Stats

Share

Embed

Customize your widget with the following options, then copy and paste the code below into the HTML of your page to embed this item in your website.
                        
                            <div id="ubcOpenCollectionsWidgetDisplay">
                            <script id="ubcOpenCollectionsWidget"
                            src="{[{embed.src}]}"
                            data-item="{[{embed.item}]}"
                            data-collection="{[{embed.collection}]}"
                            data-metadata="{[{embed.showMetadata}]}"
                            data-width="{[{embed.width}]}"
                            async >
                            </script>
                            </div>
                        
                    
IIIF logo Our image viewer uses the IIIF 2.0 standard. To load this item in other compatible viewers, use this url:
http://iiif.library.ubc.ca/presentation/dsp.50878.1-0041986/manifest

Comment

Related Items